Small Engine

Small Engine Troubleshooting Problems? Ask a Mechanic Now.

Ask an Expert,
Get an Answer ASAP!

Hank I have a Onan marquis gold 5.5 HGJAB it will run 20 and…

Customer Question
Hank I have a Onan marquis...
Hank
I have a Onan marquis gold 5.5 HGJAB it will run 20 and stop.
Lots of new fuel, new fuel filters in line and carbriator .
It not hot,
Thanks
Will
Submitted: 2 years ago.Category: Small Engine
Show More
Show Less
Ask Your Own Small Engine Question
Answered in 4 hours by:
3/11/2016
Technician: Hank F., Technician replied 2 years ago
Hank F.
Hank F., Technician
Category: Small Engine
Satisfied Customers: 15,995
Experience: Certified on Onan and Generac generators
Verified

What is the full model number of the genset?

What fault code are you getting?

Ask Your Own Small Engine Question
Customer reply replied 2 years ago
Model no : 5.5 HGJAB
Serial # *****
Technician: Hank F., Technician replied 2 years ago

That is only a partial model number. I need the full number.

What fault code are you getting?

Ask Your Own Small Engine Question
Was this answer helpful?

How JustAnswer works

step-image
Describe your issueThe assistant will guide you
step-image
Chat 1:1 with a technicianLicensed Experts are available 24/7
step-image
100% satisfaction guaranteeGet all the answers you need
Ask Curtis B. Your Own Question
Curtis B.
Curtis B.
Curtis B., Technician
Category: Small Engine
Satisfied Customers: 15,342
15,342 Satisfied Customers
Experience: have worked on and around most engine models for 35 yrs./Polaris ATV expert

Curtis B. is online now

A new question is answered every 9 seconds

How JustAnswer works:

  • Ask an ExpertExperts are full of valuable knowledge and are ready to help with any question. Credentials confirmed by a Fortune 500 verification firm.
  • Get a Professional AnswerVia email, text message, or notification as you wait on our site. Ask follow up questions if you need to.
  • 100% Satisfaction GuaranteeRate the answer you receive.

JustAnswer in the News:

Ask-a-doc Web sites: If you've got a quick question, you can try to get an answer from sites that say they have various specialists on hand to give quick answers... Justanswer.com.
JustAnswer.com...has seen a spike since October in legal questions from readers about layoffs, unemployment and severance.
Web sites like justanswer.com/legal
...leave nothing to chance.
Traffic on JustAnswer rose 14 percent...and had nearly 400,000 page views in 30 days...inquiries related to stress, high blood pressure, drinking and heart pain jumped 33 percent.
Tory Johnson, GMA Workplace Contributor, discusses work-from-home jobs, such as JustAnswer in which verified Experts answer people’s questions.
I will tell you that...the things you have to go through to be an Expert are quite rigorous.

What Customers are Saying:

You did one super job of explaining to me everything there is to know about this fridge. I'm looking forward to asking you questions in the future.

JimmyBagley, IA

Wonderful service, prompt, efficient, and accurate. Couldn't have asked for more. I cannot thank you enough for your help.

Mary C.Freshfield, Liverpool, UK

This expert is wonderful. They truly know what they are talking about, and they actually care about you. They really helped put my nerves at ease. Thank you so much!!!!

AlexLos Angeles, CA

Thank you for all your help. It is nice to know that this service is here for people like myself, who need answers fast and are not sure who to consult.

GPHesperia, CA

I couldn't be more satisfied! This is the site I will always come to when I need a second opinion.

JustinKernersville, NC

Just let me say that this encounter has been entirely professional and most helpful. I liked that I could ask additional questions and get answered in a very short turn around.

EstherWoodstock, NY

Thank you so much for taking your time and knowledge to support my concerns. Not only did you answer my questions, you even took it a step further with replying with more pertinent information I needed to know.

RobinElkton, Maryland

< Previous | Next >

Meet the Experts:

Curtis B.

Curtis B.

Technician

15,342 satisfied customers

have worked on and around most engine models for 35 yrs./Polaris ATV expert

Rick

Rick

Factory Authorized Trainer

4,218 satisfied customers

Outdoor Power Equipment technical trainer since 1990, covering eight states.

Jon K.

Jon K.

Small Engine Diagnostic Expert

2,995 satisfied customers

Gold certified Stihl tech, Service Manager for a rental/repair shop.Certified in most small engines

James W

James W

Small Engine Troubleshooting Expert

2,986 satisfied customers

7 years as Mechanic & Parts Manager for Brother who has Owned Lawn & Garden Repair shop for 35 years

Vince O.

Vince O.

Small Engine Technician

2,927 satisfied customers

Over 30 years experience repairing lawn and garden equipment. Chainsaws, mowers,blowers and trimmers

Wayne

Wayne

Engine Rebuilder

2,041 satisfied customers

many years on egine rebuilding, lawn mower,roto tiller,Truck,and small engines

RUSS

RUSS

SERVICE TECHNICIAN

1,723 satisfied customers

28 YEAR SERVICE TECHNICIAN

< Previous | Next >

Related Small Engine Questions
I have an onan marquise gold 5500. I put a new on it, new
I have an onan marquise gold 5500. I put a new carburetor on it, new plugs oil filter fuel filter and fuel pump. The generator bogs down when I turn the main AC on and trips the 30 amp breaker on the … read more
Hank F.
Hank F.
Technician
15,995 satisfied customers
I have a onan 5500 Marquis gold in a 2003 motorhome. the gen
I have a onan 5500 Marquis gold in a 2003 motorhome. the gen has 300 hours on it. I have replaced the carb, fuel pump, filter, cleaned the rings, put in new plugs, new filter. I will run great until I… read more
Hank F.
Hank F.
Technician
15,995 satisfied customers
Hank / Pearl - down in Tyler, TX. I have a an Onan Marquis
Hello Hank / Pearl - this is Enrique down in Tyler, TX. I have a an Onan Marquis 5500 in an RV that runs for a while then shuts down. The RV is 15 years old and I don't know what, if any, maintenance … read more
Hank F.
Hank F.
Technician
15,995 satisfied customers
I have an Onan Marquis Gold 5500 HGJAB. I am fairly certain
I have an Onan Marquis Gold 5500 HGJAB. I am fairly certain that the low oil pressure sensor failed and I have mechanical damage, most likely piston rod(s). What is is the typical repair cost for this… read more
Curtis B.
Curtis B.
Technician
Associate Degree
15,342 satisfied customers
I have a 5500 onan marquis generator, problem is it shuts
I have a 5500 onan marquis generator, problem is it shuts off durring operation. Oil it to the top of the full mark and new Fuel filters and air filters are new Seems to happen under a load Any ideas?… read more
Hank F.
Hank F.
Technician
15,995 satisfied customers
2005 Onan 5500 Marquis Gold, runs about 20 to 30 minutes and
2005 Onan 5500 Marquis Gold, runs about 20 to 30 minutes and shuts down with code 36. Will restart after cools down. However, when it stops there is no fuel in the carburetor bowl- observed by opening… read more
Hank F.
Hank F.
Technician
15,995 satisfied customers
My onan 5500 will not run properly, I just purchased my rv
My onan 5500 will not run properly, I just purchased my rv and the previous owner had replaced the carb , he replased the carb and said it was working fine when he stored it , he also said he drained … read more
Hank F.
Hank F.
Technician
15,995 satisfied customers
I HAVE A ONAN GENERATOR THAT IS FLASHING A CODE OF 3 AND 6
I HAVE A ONAN GENERATOR THAT IS FLASHING A CODE OF 3 AND 6 WHAT DOES THAT MEAN and WHAT DO I HAVE TO DO TO FIX IT… read more
Hank F.
Hank F.
Technician
15,995 satisfied customers
Hello there Hank, you obviously dont know me, but you have
Hello there Hank, you obviously don't know me, but you have helped me a great deal from your previous diags and fixes. I own a repair shop and have a customer with a genset problem. It is an Onan Marq… read more
Hank F.
Hank F.
Technician
15,995 satisfied customers
Hello Hank, My name isXXXXX have a onan 5500 and it
Hello Hank, My name isXXXXX have a onan 5500 and it has all the common problems as most. Starts up and dies after 15-20 minutes with or without a load. Replaced filters, oil, fuel, pump works, replace… read more
Hank F.
Hank F.
Technician
15,995 satisfied customers
I have an Onan Marquis Gold Genset 5500 model HGJAB that will
I have an Onan Marquis Gold Genset 5500 model HGJAB that will run and stop after 30 minutes up to 3hrs of running, but more frequently at times. I have changed the pump filter, installed the adapter t… read more
Hank F.
Hank F.
Technician
15,995 satisfied customers
I have an Onan 5.5 KVA (marquis Gold) RV generator. I have
I have an Onan 5.5 KVA (marquis Gold) RV generator. I have had fuel issues from day one. I've blown out the carb with spray cleaner, dismantled and cleaned it (Blew out passages with compressed air as… read more
Hank F.
Hank F.
Technician
15,995 satisfied customers
I have to remove the rotor on an Onan Marquis Gold 5.5... what
I have to remove the rotor on an Onan Marquis Gold 5.5... what is the procedure. The rotor has an open circuit and need to be replace or rebuilt if possible. JG… read more
Hank F.
Hank F.
Technician
15,995 satisfied customers
I have an Onan Marquis Gold 5500 model 5.5 HGJAB-901D in my
I have an Onan Marquis Gold 5500 model 5.5 HGJAB-901D in my car trailer. It is 5 years old and has around 1750 hours on it. I perform regular oil changes, I ran the valves this spring I generally use … read more
Hank F.
Hank F.
Technician
15,995 satisfied customers
Hi I have a Marquis gold 5500 gas generator. It will start
Hi I have a Marquis gold 5500 gas generator. It will start and run for about 3 to 4 minutes then stop. I already replaced the fuel pump with a new pump, filter and adapter that onan replaced the(NNN) … read more
Hank F.
Hank F.
Technician
15,995 satisfied customers
I have onan model 1 5.5 hgjab-1038 it runs till it warms up
I have onan model 1 5.5 hgjab-1038 it runs till it warms up then dies ,it will run if you hold choke down. what to try change one filter… read more
Hank F.
Hank F.
Technician
15,995 satisfied customers
The genset in my motorhome was not run for over a year. A local
The genset in my motorhome was not run for over a year. A local Service center said the carb and needle valve probably 'varnished' and that I could clean it myself with carb cleaner. I removed the car… read more
Hank F.
Hank F.
Technician
15,995 satisfied customers
how do you check/replace the fuel filter on an onan generator
how do you check/replace the fuel filter on an onan generator that's built in to my RV? Thanks.… read more
Hank F.
Hank F.
Technician
15,995 satisfied customers
Disclaimer: Information in questions, answers, and other posts on this site ("Posts") comes from individual users, not JustAnswer; JustAnswer is not responsible for Posts. Posts are for general information, are not intended to substitute for informed professional advice (medical, legal, veterinary, financial, etc.), or to establish a professional-client relationship. The site and services are provided "as is" with no warranty or representations by JustAnswer regarding the qualifications of Experts. To see what credentials have been verified by a third-party service, please click on the "Verified" symbol in some Experts' profiles. JustAnswer is not intended or designed for EMERGENCY questions which should be directed immediately by telephone or in-person to qualified professionals.

Disclaimer: Information in questions, answers, and other posts on this site ("Posts") comes from individual users, not JustAnswer; JustAnswer is not responsible for Posts. Posts are for general information, are not intended to substitute for informed professional advice (medical, legal, veterinary, financial, etc.), or to establish a professional-client relationship. The site and services are provided "as is" with no warranty or representations by JustAnswer regarding the qualifications of Experts. To see what credentials have been verified by a third-party service, please click on the "Verified" symbol in some Experts' profiles. JustAnswer is not intended or designed for EMERGENCY questions which should be directed immediately by telephone or in-person to qualified professionals.

Show MoreShow Less

Ask Your Question

x