RV

Have RV questions? Ask an RV mechanic online.

Connect one-on-one with {0} who will answer your question

This answer was rated:

2006 Winnebago Journey 34H- hydraulic system 325 Hydraulic…

2006 Winnebago Journey 34H- hydraulic...
2006 Winnebago Journey 34H- hydraulic system 325
Hydraulic pump wouldnts stop when I put the leveling jacks down. went on for 2-3 minutes, got very hot and smoked, then shut down. Jacks self retracted.

I think I need a new HYDRAULIC PUMP and/or RELAY SWITCH- What is the part number and where can I get it
Show More
Show Less
Ask Your Own RV Question
Answered in 8 minutes by:
8/21/2012
RV Mechanic: Robert, RV Mechanic replied 10 years ago
Robert
Robert, RV Mechanic
Category: RV
Satisfied Customers: 24,313
Experience: 23 yrs. RV experience including Cummins North West, Country Coach, Monaco Coach - vendor certified.
Verified

Hi There.....

I think on this one I would contact HWH directly, I have never seen one that kept running after the jacks are down, if the pump relay stuck then it might be and issue and I would test that out and see if you have continuity through the large post, it looks like a solenoid valve, the other issue is the controls, if it is getting a signal to run the jacks after they are down, I doubt the pump is at fault but could be damaged if it smoked. HWH does have a tech support line but many times you have to wait for a few days for a call back. The system is a bit complex, it has a control box with the leveling sensor also.... HERE is a service manual that might help in testing some items out.... Robert

Also normally for each HWH component you should see an AP number that is on a sticker for the jacks, control box and motor.... That would be the part number....

Robert
Robert, RV Mechanic
Category: RV
Satisfied Customers: 24,313
Experience: 23 yrs. RV experience including Cummins North West, Country Coach, Monaco Coach - vendor certified.
Verified
Robert and 87 other RV Specialists are ready to help you
Ask your own question now
Was this answer helpful?

How JustAnswer works

step-image
Describe your issueThe assistant will guide you
step-image
Chat 1:1 with a rv mechanicLicensed Experts are available 24/7
step-image
100% satisfaction guaranteeGet all the answers you need
Ask Robert Your Own Question
Robert
Robert
Robert, RV Mechanic
Category: RV
Satisfied Customers: 24,313
24,313 Satisfied Customers
Experience: 23 yrs. RV experience including Cummins North West, Country Coach, Monaco Coach - vendor certified.

Robert is online now

Related RV Questions
Rear jacks on our sunstar 2017 Winnebago will not retract
Rear jacks on our sunstar 2017 Winnebago will not retract fully. Down about an inch from front jacks. Hydraulic fluid appears full. Every time we go around corner bells ring. Any ideas? … read more
Robert
Robert
RV Mechanic
Vocational, Technical or Trade Scho
24,313 satisfied customers
Slides won't go in or out no power to them. No power to
Checked batteries they are fully charged looking for fuse to slides … read more
KevinS121
KevinS121
Some college
2,704 satisfied customers
2006 Winnebago Journey 39K, hydraulic pump runs, slides or
2006 Winnebago Journey 39K, hydraulic pump runs, slides or jacks don't move. HWH pump AP34402 … read more
Robert
Robert
RV Mechanic
Vocational, Technical or Trade Scho
24,313 satisfied customers
Jacks Down alarm goes off on bigger bumps on highway.
Jacks Down alarm goes off on bigger bumps on highway. Checked reservoir level... all OK. Assuming it's one of the jack sensors... but … read more
Robert
Robert
RV Mechanic
Vocational, Technical or Trade Scho
24,313 satisfied customers
One leveling slips back down after retracted. No leaks
One leveling jack slips back down after retracted. No leaks found. The jack is only 4 years old. … read more
Randall
Randall
RVIA Certification
Vocational, Technical or Trade Scho
26,243 satisfied customers
The jacks came 2" off the ground when I was retracting them
The jacks came 2 " off the ground when I was retracting them and they stopped there. It is a 2003 Winnebago Journey DL … read more
Robert
Robert
RV Mechanic
Vocational, Technical or Trade Scho
24,313 satisfied customers
2005 Winnebago Journey Hydraulic leveling/slide out system
2005 Winnebago Journey Hydraulic leveling/slide out system stopped working. Suspect Pump motor fuse. I can hear a relay clicking when actuating the remote switch, but pump does not run. Priority 1 is … read more
Randall
Randall
RVIA Certification
Vocational, Technical or Trade Scho
26,243 satisfied customers
I have a Winnebago Brave, the jacks retract, there are no
I have a Winnebago Brave, the jacks retract, there are no leaks and the hydraulic tank is full, what could be the problem… read more
Robert
Robert
RV Mechanic
Vocational, Technical or Trade Scho
24,313 satisfied customers
Levelers won't come down. Parking brake is on. Hydraulic
Levelers won't come down. Parking brake is on. Hydraulic pump comes on them shut off after a couple minutes. Green travel light is illuminated in controller. … read more
Robert
Robert
RV Mechanic
Vocational, Technical or Trade Scho
24,313 satisfied customers
I have a 2004 Journey with hydraulic slideouts. There
I have a 2004 Journey with hydraulic slideouts. There appears to be 2 "dogs" that remain extended on the front system that will not allow the complete retraction of the slide. Is there a way to mechan… read more
Robert
Robert
RV Mechanic
Vocational, Technical or Trade Scho
24,313 satisfied customers
2006 Winnebago Journey 39K ~ How difficult is it to change
2006 Winnebago Journey 39K ~ How difficult is it to change the front leveling jacks? Could a superb truck shop do it? Or do I need an RV shop?… read more
Randall
Randall
RVIA Certification
Vocational, Technical or Trade Scho
26,243 satisfied customers
I have a 2003 Winnebago Adventurer that both slides went out
I have a 2003 Winnebago Adventurer that both slides went out but will not retract. The same hydraulic pump and system runs the leveling jacks and they work fine. Both rooms have independent switches a… read more
Joe
Joe
Owner Kingsland Auto & Marine Services
Vocational, Technical or Trade Scho
1,617 satisfied customers
10 minutes..the jacks, I release the parking brake..alarm..illuminated
I have a 2006 37 foot Georgetown with a LCI 3 slide system. Recently, 10 minutes after retracting the jacks, I release the parking brake and the system went into alarm mode. The jacks were retracted, … read more
Randall
Randall
RVIA Certification
Vocational, Technical or Trade Scho
26,243 satisfied customers
Journey..reverse..Both tv and sat antenna are cranked down.So I
2000 Winnedago Journey getting warning chime in reverse or drive. I get the same chime when operating the leveling system. Both tv and sat antenna are cranked down. So I think it may be the jack syste… read more
Robert
Robert
RV Mechanic
Vocational, Technical or Trade Scho
24,313 satisfied customers
I bought a 05 Winnebago Journey 34H, 6/09..600 miles
I bought a '05 Winnebago Journey 34H, 6/09. Barely used, it had 10,600 miles on it. My problem is with the HWH levelers, model 325. They go down fine. But the rear two stick about two inches from the … read more
Robert
Robert
RV Mechanic
Vocational, Technical or Trade Scho
24,313 satisfied customers
2005 winnebago adventurer that when we put out the room slide..bolt
Can you help us, we have a 2005 winnebago adventurer that when we put out the room slide it went out about 9 inches and stopped. Then my husband tried the others and they would not go out. So we need … read more
Nick
Nick
RVIA Certification
HND (higher national diploma)
664 satisfied customers
A 2005 Winnebago Sightseer with hydraulic jacks..retract..refilled
I have a 2005 Winnebago Sightseer with hydraulic jacks that will not retract. I have refilled the fluid which was low with no luck. I was told to push them down, use WD40, and maybe they would come up… read more
Michael Reush
Michael Reush
Master Technician
High School or GED
3,175 satisfied customers
winnebago..gas engine..kwikee M-3530-0101 hydraulic leveling Jacks
2005 winnebago R29 classA gas engine I have the Kwikee M-3530-0101 hydraulic leveling Jacks and when I try to put the jacks up the pump motor does not shut off it use to automaticly shot off before… read more
Robert
Robert
RV Mechanic
Vocational, Technical or Trade Scho
24,313 satisfied customers
Disclaimer: Information in questions, answers, and other posts on this site ("Posts") comes from individual users, not JustAnswer; JustAnswer is not responsible for Posts. Posts are for general information, are not intended to substitute for informed professional advice (medical, legal, veterinary, financial, etc.), or to establish a professional-client relationship. The site and services are provided "as is" with no warranty or representations by JustAnswer regarding the qualifications of Experts. To see what credentials have been verified by a third-party service, please click on the "Verified" symbol in some Experts' profiles. JustAnswer is not intended or designed for EMERGENCY questions which should be directed immediately by telephone or in-person to qualified professionals.

JustAnswer in the News:

Ask-a-doc Web sites: If you've got a quick question, you can try to get an answer from sites that say they have various specialists on hand to give quick answers... Justanswer.com.
JustAnswer.com...has seen a spike since October in legal questions from readers about layoffs, unemployment and severance.
Web sites like justanswer.com/legal
...leave nothing to chance.
Traffic on JustAnswer rose 14 percent...and had nearly 400,000 page views in 30 days...inquiries related to stress, high blood pressure, drinking and heart pain jumped 33 percent.
Tory Johnson, GMA Workplace Contributor, discusses work-from-home jobs, such as JustAnswer in which verified Experts answer people’s questions.
I will tell you that...the things you have to go through to be an Expert are quite rigorous.

What Customers are Saying:

Excellent reply, and also very quick. Really sounds like the Expert knows what he is talking about. I will be back to use your service when I need more help with my RV.

DutchUSA

Highly recommend this RV expert. Prompt, good and detailed answers were given. Very willing to help with genuine concern. I will ask for him next time.

JackUSA

I would (and have) recommend your site to others I was quite satisfied with the quality of the information received, the professional with whom I interacted, and the quick response time. Thanks, and be sure that I'll be back whenever I need a question answered in a hurry.

Stephanie PElm City, NC

used your service this weekend with "Trecers" help. thank you ,thank you, thank you. replaced an A/C fan motor. Local Auto Zone had part. $15.00 "tracer" fee and $40.00 for parts, I saved several hundreds of dollers at a shop. i will recommend you and use you in the future.

David L.Richmond, TX

9 dollars, 2 hours of my time, and I drove away. Your diagnosis was right on the mark. Thank you so much.

PhilMarysville, CA

Lurch. Thank you very much. I had real doubts about this website but your promptness of response, quick followup and to the point answer with picture was incredible.

CharlesWalnut Creek, CA

As a single woman, I really appreciate an excellent and affordable opinion.
Thank you Geordie, I will not hesitate to contact justanswer in the future!

SueCharleston, WV

< Previous | Next >

Meet the Experts:

gene

gene

RV Mechanic

1,100 satisfied customers

28 yrs exp in the industry

Nick

Nick

RVIA Certification

664 satisfied customers

5 years RV repair and reconstruction, Fleetwood RV Training course completion.

Steve F.

Steve F.

RVIA Certification

443 satisfied customers

Journeyman and Master RV technician, Mechanical & Aerospace Engineer. RVIA Technical Consultant

Randall

Randall

RVIA Certification

26,243 satisfied customers

RVDA/RVIA Master Certified Technician with many years experience.

Chris (aka-Moose)

Chris (aka-Moose)

RV Mechanic

2,418 satisfied customers

24 years of experience diagnosing & repairing

Wayne

Wayne

RV Mechanic

2,163 satisfied customers

Work on several type of Rv engine, Trans, brakes

D. Wood

D. Wood

RV Parts Store Owner

205 satisfied customers

Slide Out, Jack & Hitch Specialist

< Previous | Next >

Disclaimer: Information in questions, answers, and other posts on this site ("Posts") comes from individual users, not JustAnswer; JustAnswer is not responsible for Posts. Posts are for general information, are not intended to substitute for informed professional advice (medical, legal, veterinary, financial, etc.), or to establish a professional-client relationship. The site and services are provided "as is" with no warranty or representations by JustAnswer regarding the qualifications of Experts. To see what credentials have been verified by a third-party service, please click on the "Verified" symbol in some Experts' profiles. JustAnswer is not intended or designed for EMERGENCY questions which should be directed immediately by telephone or in-person to qualified professionals.

Show MoreShow Less

Ask Your Question

x