Heavy Equipment

Heavy equipment repair questions? Ask an Expert now.

Ask an Expert,
Get an Answer ASAP!

Related Heavy Equipment Questions
I have a large with a cat 3204 non turbo engine would you
hello again, I have a large wood chipper with a cat 3204 non turbo engine would you have the service manual for this or help with it. customer droped off machine runs rough at start up and leaks fuel … read more
catmastertech
catmastertech
Field service technician
Vocational, Technical or Trade Scho
1,287 satisfied customers
I read an answer you posted almost 4 years ago on just
I read an answer you posted almost 4 years ago on just answer. heavy equipment regarding a Caterpillar 3208 that would not start. I have the same problem. I pulled in the driveway and shut it off, wne… read more
Wayne
Wayne
Journeyman
Vocational, Technical or Trade Scho
3,101 satisfied customers
83 track vehicle with 2500 hours on the 3208 non-turbo engine
I just purchased a 83 track vehicle with 2500 hours on the 3208 non-turbo engine. I have no manuals. The vehicle was sitting for several (unknown years). The engine runs. I plan to use the vehicle for… read more
Cat Man
Cat Man
Caterpillar Engine Expert
Vocational, Technical or Trade Scho
9,514 satisfied customers
I need to find out what the engine family name is XXXXX XXXXX caterpillar
I need to find out what the engine family name is XXXXX XXXXX caterpillar engine make. Vin is 1FDYL80U0HVA01655. Vehicle year 1986. Vehicle make is Ford. Engine year 1986. Engine make is Caterpillar. … read more
Wayne
Wayne
Journeyman
Vocational, Technical or Trade Scho
3,101 satisfied customers
Lift..It sputters and smokes pretty bad...starting fluid
We have a 2003 Lull 944 E 42 Lift. It sputters and smokes pretty bad. It needs a squirt of starting fluid to get it going most of the time. It will run like this for months then run like new for a whi… read more
Curtis B.
Curtis B.
service manager
Associate Degree
2,283 satisfied customers
81 ford: a 3208 cat non turbo fuel leaks..seal..timing..regal
i have a 81 ford 8000 series with a 3208 cat non turbo fuel leaks hevily from bottom of injection pump area when started suspect possible worn/hardened pump seal or internal pump wear as cause of conc… read more
Cat Man
Cat Man
Caterpillar Engine Expert
Vocational, Technical or Trade Scho
9,514 satisfied customers
3208 marine: The throttle linkage is OK, the fuel filter is..turbo
After adjusting the valve lash as you specified and reinstalling the head, the 1987 3208 marine engine will not go over 1500 RPM. The throttle linkage is OK, the fuel filter is new and the turbo spins… read more
catmastertech
catmastertech
Field service technician
Vocational, Technical or Trade Scho
1,287 satisfied customers
Marine: drives..The center engine is rated at 425hp
I have a boat with three 3208 TA Marine Cats with arneson surface drives. The center engine is rated at 425hp. I have owned the boat for about three months. I have pulled injectors and had them cleane… read more
Cat Man
Cat Man
Caterpillar Engine Expert
Vocational, Technical or Trade Scho
9,514 satisfied customers
moter has a fuel pump to push the fuel..fuel shutoff seilode
i have 3208 in my combine it shut down like you turned off the key notice that when i take off the filter it not allthe way full and would like to know if this moter has a fuel pump to push the fuel t… read more
Cat Man
Cat Man
Caterpillar Engine Expert
Vocational, Technical or Trade Scho
9,514 satisfied customers
Turbo, the engine speed is droping..servicing..diesel
cat 3208 generator set with turbo, the engine speed is droping while loading the generator. the fuel injection pump is installed after servicing. diesel filter is new . there is no diesel passing out … read more
Cat Man
Cat Man
Caterpillar Engine Expert
Vocational, Technical or Trade Scho
9,514 satisfied customers
A 1989 3208 TURBO CAT MOTOR THAT DROP A VALVE THROUGH A PISTON I
I HAVE A 1989 3208 TURBO CAT MOTOR THAT DROP A VALVE THROUGH A PISTON I WAS WONDERING IF I CAN TAKE A 3208 NATURAL WITH THE SAME HP AND PUT MY TURBO ON IT THANKS JOHN… read more
Air Brakes and other fun stuff
Air Brakes and other fun stuff
Mechanic
Vocational, Technical or Trade Scho
36 satisfied customers
Diesel engine..batteries..The starter and alternator were just rebuilt
Blue Bird Wanderlodge 3208 Cat diesel engine. charged all batteries, went out this AM to start, it started initially, ran funny than sputtered and died. The starter and alternator were just rebuilt. C… read more
don
don
fleet superintendent
Vocational, Technical or Trade Scho
12 satisfied customers
Ran fine but then sat..Starts and dies within a couple seconds.
Have an older Cat 3208 NA in snow plow truck. Ran fine but then sat for 2 years and now it will not run. Starts and dies within a couple seconds. Did basic fuel troubleshooting and all seems ok. Hunch… read more
Wayne
Wayne
Journeyman
Vocational, Technical or Trade Scho
3,101 satisfied customers
GMC: Caterpillar..The Truck was to working fine but righ..noise
Hi, I have GMC 7000 Engine Caterpillar 3208. Year 1986 Fiing order 12734568. The Truck was to working fine but righ now,have a noise inside the engine.… read more
Heath
Heath
Service Tech
Diesel technology
62 satisfied customers
core..vin..fuel problems leaking and sucking air, ect found none
i have a 1999 fl70 with a 3126 caterpillar engine core #(NNN) NNN-NNNNlast of the vin b45199. I purchased the truck 7 months ago . From the beginning the idle has been up and down, i checked for fuel … read more
Diesel Service
Diesel Service
Owner/Tech
Vocational, Technical or Trade Scho
133 satisfied customers
Sputter..I spray ether over the intake while cranking, it
I have a Cat 3208 that refuses to start... not a putter. sputter or anything! If I spray ether over the intake while cranking, it will attempt to start and run until I cease spraying. The fuel solenoi… read more
Dan Boy
Dan Boy
Amusement ride technician
High School or GED
110 satisfied customers
non turbo..would not start without ether but runs great after a shot.
I have an older cat 3208 non turbo non comp. ok just had pump resealed by cat dealer. would not start without ether but runs great after a shot. figure it is losing prime somewhere i replaced the prim… read more
dieseltech
dieseltech
Owner
Vocational, Technical or Trade Scho
14 satisfied customers
marine: that has installed cummings 6bta..MI Diamond Series engines.
I am looking at a marine vessel that has installed Cummings 6BTA-5.9 MI Diamond Series engines. Do they have any weak points? And what might they be. They have 300 hours of operation and state they pr… read more
dieseltech
dieseltech
Owner
Vocational, Technical or Trade Scho
14 satisfied customers
Disclaimer: Information in questions, answers, and other posts on this site ("Posts") comes from individual users, not JustAnswer; JustAnswer is not responsible for Posts. Posts are for general information, are not intended to substitute for informed professional advice (medical, legal, veterinary, financial, etc.), or to establish a professional-client relationship. The site and services are provided "as is" with no warranty or representations by JustAnswer regarding the qualifications of Experts. To see what credentials have been verified by a third-party service, please click on the "Verified" symbol in some Experts' profiles. JustAnswer is not intended or designed for EMERGENCY questions which should be directed immediately by telephone or in-person to qualified professionals.

JustAnswer in the News:

Ask-a-doc Web sites: If you've got a quick question, you can try to get an answer from sites that say they have various specialists on hand to give quick answers... Justanswer.com.
JustAnswer.com...has seen a spike since October in legal questions from readers about layoffs, unemployment and severance.
Web sites like justanswer.com/legal
...leave nothing to chance.
Traffic on JustAnswer rose 14 percent...and had nearly 400,000 page views in 30 days...inquiries related to stress, high blood pressure, drinking and heart pain jumped 33 percent.
Tory Johnson, GMA Workplace Contributor, discusses work-from-home jobs, such as JustAnswer in which verified Experts answer people’s questions.
I will tell you that...the things you have to go through to be an Expert are quite rigorous.

What Customers are Saying:

I would (and have) recommend your site to others I was quite satisfied with the quality of the information received, the professional with whom I interacted, and the quick response time. Thanks, and be sure that I'll be back whenever I need a question answered in a hurry.

Stephanie PElm City, NC

used your service this weekend with "Trecers" help. thank you ,thank you, thank you. replaced an A/C fan motor. Local Auto Zone had part. $15.00 "tracer" fee and $40.00 for parts, I saved several hundreds of dollers at a shop. i will recommend you and use you in the future.

David L.Richmond, TX

9 dollars, 2 hours of my time, and I drove away. Your diagnosis was right on the mark. Thank you so much.

PhilMarysville, CA

Lurch. Thank you very much. I had real doubts about this website but your promptness of response, quick followup and to the point answer with picture was incredible.

CharlesWalnut Creek, CA

As a single woman, I really appreciate an excellent and affordable opinion.
Thank you Geordie, I will not hesitate to contact justanswer in the future!

SueCharleston, WV

Another great insight to what may be the problem. I will have my mechanic take a look at it tomorrow. Thanks again, Frank...you do indeed know your stuff.

JimCastleberry, FL

Wonderful service, prompt, efficient, and accurate. Couldn't have asked for more. I cannot thank you enough for your help.

Mary C.Freshfield, Liverpool, UK

< Previous | Next >

Meet the Experts:

Chris (aka - Moose)

Chris (aka - Moose)

Technician

112 satisfied customers

16 years of experience

Tim

Tim

Foreman

338 satisfied customers

23 Years Heavy Equipment and Truck Repairs Shop and Field in the Minning and Construction Industry

J.R.

J.R.

Technician

148 satisfied customers

13 years as warranty technician for Detroit Diesel

Cat Man

Cat Man

Caterpillar Engine Expert

9,514 satisfied customers

23 Years Caterpillar Engine experience.

Wayne

Wayne

Journeyman

3,101 satisfied customers

34 years experiance as engine rebuild and problems.Thermo-King repair and trouble shooting.

DR.Cummins

DR.Cummins

FIELD SERVICE TECHNICIAN

2,371 satisfied customers

16 Years working on Cummins Diesel engines,

Curtis B.

Curtis B.

service manager

2,283 satisfied customers

30 years exp. with diesel engines, heavy equipment and forklifts, including lp forklifts

< Previous | Next >

Disclaimer: Information in questions, answers, and other posts on this site ("Posts") comes from individual users, not JustAnswer; JustAnswer is not responsible for Posts. Posts are for general information, are not intended to substitute for informed professional advice (medical, legal, veterinary, financial, etc.), or to establish a professional-client relationship. The site and services are provided "as is" with no warranty or representations by JustAnswer regarding the qualifications of Experts. To see what credentials have been verified by a third-party service, please click on the "Verified" symbol in some Experts' profiles. JustAnswer is not intended or designed for EMERGENCY questions which should be directed immediately by telephone or in-person to qualified professionals.

Show MoreShow Less

Ask Your Question

x