Dodge

Dodge Repair Questions? Ask a Mechanic for Answers ASAP

Ask an Expert,
Get an Answer ASAP!

Dodge
This answer was rated:

How do I replace the climate control module on a Dodge

Caravan ES 2002...
How do I replace the climate control module on a Dodge Caravan ES 2002
Ask Your Own Dodge Question
Answered in 10 minutes by:
4/16/2010
Stonyman
Stonyman, Ase Master Technician
Category: Dodge
Satisfied Customers: 723
Experience: Certified Ase Master, 23 years exp. Pa state and emissions lic. Specializing in Chrysler/Dodge/Jeep
Verified

Hi. Here is the entire procedure. It's not bad at all. Good luck and thank you for using JA!

1 - LOWER INSTRUMENT PANEL
2 - INSTRUMENT PANEL CENTER BEZEL
3 - CUPHOLDER

REMOVAL

  1. Disconnect and isolate the battery negative cable.
  2. Insert the trim stick (special tool #C-4755) or equivalent between access cover and center bezel gently pry outward.
  3. Carefully pry the access cover from the instrument panel (INSTRUMENT PANEL CENTER BEZEL).
  4. Remove the two center bezel attaching screws.
  5. Using a trim stick or equivalent, gently pry out on the edge of the instrument panel center bezel and pull outward.
  6. Disconnect the wire connectors to the accessory switches and HVAC control.
  7. Remove the instrument panel center bezel from the vehicle.
  • Place the instrument panel center bezel unit face down on a suitable work surface. Take the proper precautions to protect the center bezel from cosmetic damage.
  • If the vehicle is equipped with the optional Automatic Temperature Control (ATC) system, disconnect the infrared sensor jumper harness connector from the receptacle on the back of the heater-A/C control (Heater-A/C Control).
  • Remove the six screws that secure the heater-A/C control to the back of the instrument panel center bezel.
  • Remove the heater-A/C control from the instrument panel center bezel.
  • 1 - INFRARED SENSOR CONNECTOR (ATC ONLY)
    2 - INFRARED SENSOR HARNESS (ATC ONLY)
    3 - A/C-HEATER CONTROL
    4 - SCREW (6)
    5- INSTRUMENT PANEL CENTER BEZEL

    Ask Your Own Dodge Question
    Customer reply replied 7 years ago
    The problem has been is it wont shut if you hit the power button and the variable speed fan will not adjust the fan motor. It just wants to run on high speed even if it is in the off mode. Also can you tell me about how much a module will run and is there a good website to get one from

    This sounds like a bad module. We had on like this about 2 weeks ago and a module fixed it.

    I'm not sure about prices, as I don't work in parts. You could call your dealer to get an idea of the high price and go from there.

    Stonyman
    Stonyman, Ase Master Technician
    Category: Dodge
    Satisfied Customers: 723
    Experience: Certified Ase Master, 23 years exp. Pa state and emissions lic. Specializing in Chrysler/Dodge/Jeep
    Verified
    Stonyman and 87 other Dodge Specialists are ready to help you
    Ask your own question now
    Ask Stonyman Your Own Question
    Stonyman
    Stonyman
    Stonyman, Ase Master Technician
    Category: Dodge
    Satisfied Customers: 723
    723 Satisfied Customers
    Experience: Certified Ase Master, 23 years exp. Pa state and emissions lic. Specializing in Chrysler/Dodge/Jeep

    Stonyman is online now

    A new question is answered every 9 seconds

    How JustAnswer works:

    • Ask an ExpertExperts are full of valuable knowledge and are ready to help with any question. Credentials confirmed by a Fortune 500 verification firm.
    • Get a Professional AnswerVia email, text message, or notification as you wait on our site. Ask follow up questions if you need to.
    • 100% Satisfaction GuaranteeRate the answer you receive.

    JustAnswer in the News:

    Ask-a-doc Web sites: If you've got a quick question, you can try to get an answer from sites that say they have various specialists on hand to give quick answers... Justanswer.com.
    JustAnswer.com...has seen a spike since October in legal questions from readers about layoffs, unemployment and severance.
    Web sites like justanswer.com/legal
    ...leave nothing to chance.
    Traffic on JustAnswer rose 14 percent...and had nearly 400,000 page views in 30 days...inquiries related to stress, high blood pressure, drinking and heart pain jumped 33 percent.
    Tory Johnson, GMA Workplace Contributor, discusses work-from-home jobs, such as JustAnswer in which verified Experts answer people’s questions.
    I will tell you that...the things you have to go through to be an Expert are quite rigorous.

    What Customers are Saying:

    I AM VERY GLAD THAT I TOOK A CHANCE ON YOUR PROBLEM SOLVING SKILLS. I WAS SUCCESSFUL IN REPLACING THE FUEL PUMP. MY TRUCK RUNS LIKE A CLOCK. IT RUNS LIKE THE DAY I BOUGHT IT. NO LUNGING FORWARD, THE TURBO REACTS THE SECOND I STOMP ON THE GAS, AND IT HAS A LOT MORE POWER AND EVEN SOUNDS BETTER TO ME. IT SAVED ABOUT $500.00 BY DOING THE WORK MYSELF. I GIVE YOU ALL THE CREDIT FOR YOUR DIAGNOSING THE PROBLEM, JUST FROM THE SYMPTONS I GAVE YOU OVER THE e MAIL. I WILL USE YOUR WEB SITE AGAIN AND REFER MY FRIENDS. THANKS SO MUCH FOR THE HELP.

    TOM WHITTAKERUSA

    Just a quick line to tell you how pleased I am to have my brakes working properly after all this time. Your answer was what I needed. I would certainly recommend you highly. God bless!

    Rev. Jerry BaysingerHolts Summit, Mo

    I recently asked a question about my 2005 dodge ram, and I just wanted to let my Expert know that he hit the nail squarely on the head with his answer. I wanted to thank him again.

    GregPittsburgh, PA

    Just a quick line to tell you how pleased I am to have my brakes working properly after all this time. Your answer was what I needed. I would certainly recommend you highly. God bless!

    JerryHolts Summit, MO

    I was skeptical at first but thought I'd give it a try. I was pleasantly surprised. Your site actually is a quality service that I would recommend to others in a heartbeat.

    StanSayre, PA

    Wonderful service, prompt, efficient, and accurate. Couldn't have asked for more. I cannot thank you enough for your help.

    Mary C.Freshfield, Liverpool, UK

    This expert is wonderful. They truly know what they are talking about, and they actually care about you. They really helped put my nerves at ease. Thank you so much!!!!

    AlexLos Angeles, CA

    < Previous | Next >

    Meet the Experts:

    Jerry

    Jerry

    Master Mechanic

    1,754 satisfied customers

    ASE Master tech, 30 years exp. troubleshooter, driveability tech

    Chris

    Chris

    Shop Foreman

    6,753 satisfied customers

    Dodge/Cummins and Chrysler Certified Master Tech

    Mopar Certified

    Mopar Certified

    Dodge Technician

    5,939 satisfied customers

    24 Year Chrysler/Dodge Certified Specialist

    moparfl

    moparfl

    ASE Certified Technician

    3,292 satisfied customers

    ASE Master Tech Gold level Chrysler Status 30 years dealership exp

    Dodgerench

    Dodgerench

    ASE Certified Technician

    2,814 satisfied customers

    30+ years Dodge/Chrysler exp., ASE Master with L1 certification. Driveability/ combustion specialist

    Tim Mohr

    Tim Mohr

    ASE MASTER TECH

    2,322 satisfied customers

    30 YRS EXPERIENCE, FOREIGN AND DOMESTIC, GAS AND DEISEL

    Don - Mo Lurch

    Don - Mo Lurch

    Aftermarket & Factory Electronics

    1,568 satisfied customers

    Cert. Dodge & Chrysler Warnty, Heavy Line Mech, Mobile Electronics. Sales, Installation & Repair for 30 years

    < Previous | Next >

    Related Dodge Questions
    I installed a new battery and alternator after the battery
    I installed a new battery and alternator after the battery was discharging and battery instrument light came on, and everything was fine. When I went to start it a week later, there was no electrical … read more
    Mechanic01
    Mechanic01
    1,736 satisfied customers
    Not starting. get clicking sound under the battery. lights
    not starting. get clicking sound under the battery. lights come on inside but go out if try to start. … read more
    Tim Mohr
    Tim Mohr
    ASE MASTER TECH
    Master's Degree
    2,322 satisfied customers
    Randomly the battery goes dead and sometimes when the van is
    randomly the battery goes dead and sometimes when the van is off and key out of car the lights flash windows go down unlocks the doors its like it has a mind of its own … read more
    Chris (aka - Moose)
    Chris (aka - Moose)
    Vocational, Technical or Trade Scho
    108 satisfied customers
    What is the battery voltage regulator supposed to read at
    What is the battery voltage regulator supposed to read at the electrical connection going to the alternator? … read more
    AMEDEE
    AMEDEE
    AUTOMOTIVE TECHNICIAN
    Vocational, Technical or Trade Scho
    9,105 satisfied customers
    Just replaced the battery in the dodge ram truck, still
    Just replaced the battery in the dodge ram truck , still won't start, asking for serial code. Tried using the key in the driver door but still doesn't work. … read more
    sprinkles08
    sprinkles08
    Technician
    High School or GED
    11 satisfied customers
    2006 Dodge Charger accidently put the battery on backwards
    2006 Dodge Charger accidently put the battery on backwards now have no turn signals, horn, wipers or side mirror movement. I bet it's a relay any ideas which one it might be ?… read more
    heavy_chevy_396
    heavy_chevy_396
    Vocational, Technical or Trade Scho
    2,518 satisfied customers
    It wont start the battery is ghood there is a clicking noise
    it wont start the battery is ghood there is a clicking noise down by the shifter … read more
    Mechanic01
    Mechanic01
    1,736 satisfied customers
    The battery (new in October is completely dead and will not
    The battery (new in October is completely dead and will not jump. It just clicks … read more
    roy
    roy
    Associate Degree
    3 satisfied customers
    Battery light is on but the alternator bench tests fine. New
    battery light is on but the alternator bench tests fine. New battery. Thoughts? … read more
    AMEDEE
    AMEDEE
    AUTOMOTIVE TECHNICIAN
    Vocational, Technical or Trade Scho
    9,105 satisfied customers
    Alternator not charging battery or producing electricity to
    Alternator not charging battery or producing electricity to run truck have changed out alternator battery power control module serpentine belt serpentine belt tensioner pulley still not charging alter… read more
    Pete
    Pete
    Independent Auto Technician
    Vocational, Technical or Trade Scho
    138 satisfied customers
    The check gauges light comes on and the battery gauge goes
    the check gauges light comes on and the battery gauge goes to low. tonight, while driving, the lights when dim, the radio stopped working, all of the gauges starting blinking on and off. Is it the alt… read more
    David Craig
    David Craig
    OWNER/MECHANIC
    Associates
    4,429 satisfied customers
    No Crank no Start problem, Starter is good battery is good
    No Crank no Start problem , Starter is good battery is good problem does not occur all the time … read more
    Chris (aka - Moose)
    Chris (aka - Moose)
    Vocational, Technical or Trade Scho
    108 satisfied customers
    Won't start. I checked battery. It's ok. disconnected
    won't start. I checked battery. It's ok. disconnected battery ground cleaned contacts and cleaned battery posts. was just getting clicking when turning on ignition. but after cleaning ground connector… read more
    AMEDEE
    AMEDEE
    AUTOMOTIVE TECHNICIAN
    Vocational, Technical or Trade Scho
    9,105 satisfied customers
    2000 Dodge 3500 battery draining overnight. Trying to
    2000 Dodge 3500 battery draining overnight. Trying to determine the problem, when both batteries are hooked up there is a current draw of about .26 amps. If I isolate each battery, each individual bat… read more
    Pete
    Pete
    Independent Auto Technician
    Vocational, Technical or Trade Scho
    138 satisfied customers
    The battery warning light comes on but the battery, cables,
    The battery warning light comes on but the battery, cables, alternator are fine and it charges properly under load. … read more
    AMEDEE
    AMEDEE
    AUTOMOTIVE TECHNICIAN
    Vocational, Technical or Trade Scho
    9,105 satisfied customers
    The battery is fine, towed it to my mechanic and it's not
    the battery is fine, towed it to my mechanic and it's not the starter. Bought a new key from Dodge dealership about 2 months ago. All the dash lights come on but the truck won't turn over! … read more
    Jaybird61
    Jaybird61
    Master Automotive Mechanic
    2,240 satisfied customers
    Battery keeps dying. 99. No my in law we changed the battery
    No my in law we changed the battery 3 times took alternator to autozone said it was good … read more
    HDGENE
    HDGENE
    Master Technician/Lead Technician
    Associate Degree
    2,835 satisfied customers
    The battery light comes on. The battery is new the
    The battery light comes on. The battery is new the alternator is new and all fuses are good … read more
    David Craig
    David Craig
    OWNER/MECHANIC
    Associates
    4,429 satisfied customers
    Disclaimer: Information in questions, answers, and other posts on this site ("Posts") comes from individual users, not JustAnswer; JustAnswer is not responsible for Posts. Posts are for general information, are not intended to substitute for informed professional advice (medical, legal, veterinary, financial, etc.), or to establish a professional-client relationship. The site and services are provided "as is" with no warranty or representations by JustAnswer regarding the qualifications of Experts. To see what credentials have been verified by a third-party service, please click on the "Verified" symbol in some Experts' profiles. JustAnswer is not intended or designed for EMERGENCY questions which should be directed immediately by telephone or in-person to qualified professionals.

    Disclaimer: Information in questions, answers, and other posts on this site ("Posts") comes from individual users, not JustAnswer; JustAnswer is not responsible for Posts. Posts are for general information, are not intended to substitute for informed professional advice (medical, legal, veterinary, financial, etc.), or to establish a professional-client relationship. The site and services are provided "as is" with no warranty or representations by JustAnswer regarding the qualifications of Experts. To see what credentials have been verified by a third-party service, please click on the "Verified" symbol in some Experts' profiles. JustAnswer is not intended or designed for EMERGENCY questions which should be directed immediately by telephone or in-person to qualified professionals.

    Show MoreShow Less

    Ask Your Question

    x