Construction and Road Equipment

Construction and road equipment repair questions? Ask a mechanic ASAP

Connect one-on-one with {0} who will answer your question

Related Construction and Road Equipment Questions
I have a cat 236b. The aux hydraulics only function in one
I have a cat 236b. The aux hydraulics only function in one direction. When they do function in that direction it is stuck in full flow in that direction until you disengage the hydros as in lift the l… read more
JimmyM827
JimmyM827
Bobcat specialist
Automotive technologies
21 satisfied customers
Bobcat H2605 front base output short to battery and, H2705
Bobcat H2605 front base output short to battery and … read more
Fieldtech59
Fieldtech59
368 satisfied customers
I have a Bobcat 864 and the auxillary hydraulics are on and
I have a Bobcat 864 and the auxillary hydraulics are on and running backwards when started... almost like hoses are swapped??? When I puf the brush cutter on and start it the brush cutter is on and sp… read more
Fieldtech59
Fieldtech59
368 satisfied customers
No aux hydraulics functioning on Takeuchi TL140. Machine
No aux hydraulics functioning on Takeuchi TL140. Machine will move forward and backwards. Arms and tilt all function. No activation when I toggle the aux hydraulics. Any ideas??… read more
Daniel Wilson
Daniel Wilson
Auto Mechanics 1&2/diesel mech
1,055 satisfied customers
Ref: KX080-3/SN10797. I bought this unit when it had 4000
I bought this unit when it had 4000 hrs. Previous use was carrier for a DAH-85B Denis Cimaf mulcher. I am doing the same, however I intend to use AUX port 2 for discharge door cylinder. Original owner tied into the mulcher motor circuit and did not use AUX 2 for this. Problem: No voltage measured at the AUX 2 control valve connector when left joy stick push buttons are a pushed. Is this circuit activated from factory, or is there a field connection required? … read more
Keiphun Sowell
Keiphun Sowell
AutoDiesel Technology
1,079 satisfied customers
You were Helping me out with a CAT 248 High Flow machine. We
Hey Wayne you were Helping me out with a CAT 248 High Flow machine. We got to the point where I was going to go down by the drive motor and see if the solenoids are getting power. I just wanted to ask… read more
Wayne
Wayne
Journeyman
Vocational, Technical or Trade Scho
14,708 satisfied customers
My Takeuchi TL230 series 2 year 2014. Had a hydraulic leak.
My Takeuchi TL230 series 2 year 2014. Had a hydraulic leak. We lifted cab saw immediately where it was. Right on top. Replaced seal. Started it up. All good. Blew off dust. Put cab down. Next morning … read more
Wayne
Wayne
Journeyman
Vocational, Technical or Trade Scho
14,708 satisfied customers
Have a 2007 deere skid steer that has lost hydraulics and
Have a 2007 John deere skid steer that has lost hydraulics and throwing 2 codes. … read more
Wayne
Wayne
Journeyman
Vocational, Technical or Trade Scho
14,708 satisfied customers
On cat 277 skid steer aux hydraulics don't work. Model 277
On cat 277 skid steer aux hydraulics don't work JA: What is the complete model and serial number of your machine? Customer: Model 277 serial cnc00296 JA: Are you fixing this yourself? What have you tr… read more
Daniel Wilson
Daniel Wilson
Auto Mechanics 1&2/diesel mech
1,055 satisfied customers
I have a tl140 that seems to be leaking hydraulic fluid
I have a tl140 that seems to be leaking hydraulic fluid somewhere where it is leaking on the undercarriage plate and leaking out from there onto the ground. … read more
Wayne
Wayne
Journeyman
Vocational, Technical or Trade Scho
14,708 satisfied customers
Takeuchi TB145 Aux Hydraulics (thumb) only goes one way.
Takeuchi TB145 Aux Hydraulics (thumb) only goes one way. Checked wires from control arm to relays under the left arm (OK) but the CLOSE relay does not work. Intermittent problem - suspect relay fault.… read more
Daniel Wilson
Daniel Wilson
Auto Mechanics 1&2/diesel mech
1,055 satisfied customers
Got a Mustang MTL20 (Takeuchi TL140). The aux. hydraulics do
Got a Mustang MTL20 (Takeuchi TL140). The aux. hydraulics do not work. I have traced down the solenoid/valve that operates the aux. and opened up the control stick. What I am needing to know is how to… read more
Daniel Wilson
Daniel Wilson
Auto Mechanics 1&2/diesel mech
1,055 satisfied customers
2007 TB 175 PILOT CONTROLS QUIT RESPONDING BLADE WILL RAISE
2007 TB 175 PILOT CONTROLS QUIT RESPONDING BLADE WILL RAISE AND LOWER BUT BOOM WILL NOT OPERATE… read more
Wayne
Wayne
Journeyman
Vocational, Technical or Trade Scho
14,708 satisfied customers
2006 Takeuchi TBO16 Serial Number 11612702 I purchased the
2006 Takeuchi TBO16 Serial Number 11612702I purchased the Takeuchi TBO16 new and it currently has less than 700 hours of use. The machine is designed with a safety feature, which consists of bypassing the hydraulic system when the control consoles are raised on either side, to get on or off the machine. A few days ago, the safety feature prevented the machine from working at all, leaving me stranded on top of a pile of dirt in the middle of a driveway.We began troubleshooting and first discovered that the safety system fuse was burned out. We replaced it and it immediately failed. We checked the switches that are mounted on the control consoles, they were fine. Takeuchi service suggested putting a higher rated fuse to see if perhaps the control solenoid was pulling more than 10 amps. I tried a 30 amp and white smoke appeared from the solenoid area. We began searching the wiring harness for a short and discovered that when the solenoid was installed at the factory, one of the solenoid wires was crimped against the frame and finally the insulation wore thin and a short occurred.While I was that far into the machine, I replaced both solenoids. One is the safety bypass, the other is for the two speed control. Put the machine back together, the safety system works like new, but I have lost my high speed function. When I press the high speed button on the right track control stick, nothing happens. The rabbit indicator light does not come on and the speed stays in low range.I have the machine back apart and have checked the relays and diodes and every thing else I can think of and have found no problems.Please direct me on where the problem is.James … read more
Daniel Wilson
Daniel Wilson
Auto Mechanics 1&2/diesel mech
1,055 satisfied customers
I have a Takeuchi TL140 2006 model. It would not start
I have a Takeuchi TL140 2006 model. It would not start without using starting fluid but once it starts it runs fine. Sometimes under heavy load it shuts off also. If I run it for a while and shut it o… read more
Curtis B.
Curtis B.
Technician
Associate Degree
1,921 satisfied customers
287B with no Aux Hydraulics My machine is a 287B track
287B with no Aux Hydraulics My machine is a 287B track loader with high flow hydraulics. Earlier this year my backup warning beeper stopped working, which I dismissed as insignificant. However, the ne… read more
catmastertech
catmastertech
Field service technician
Vocational, Technical or Trade Scho
1,303 satisfied customers
I have a takeuchi TL140 that the two speed stays when you first
I have a takeuchi TL140 that the two speed stays when you first start it and warning lights in the dash are flashing . Once you run it for a while the two speed starts working and the lights go off . … read more
Daniel Wilson
Daniel Wilson
Auto Mechanics 1&2/diesel mech
1,055 satisfied customers
I have a 2007 Takeuchi TL140 skid steer.It is not turning
I have a 2007 Takeuchi TL140 skid steer. It is not turning and has no power. Charge pressure to the pilot valve is 90 psi...should be about 350. Pressure on the ports of the pilot valve is 150 on all … read more
Daniel Wilson
Daniel Wilson
Auto Mechanics 1&2/diesel mech
1,055 satisfied customers
Disclaimer: Information in questions, answers, and other posts on this site ("Posts") comes from individual users, not JustAnswer; JustAnswer is not responsible for Posts. Posts are for general information, are not intended to substitute for informed professional advice (medical, legal, veterinary, financial, etc.), or to establish a professional-client relationship. The site and services are provided "as is" with no warranty or representations by JustAnswer regarding the qualifications of Experts. To see what credentials have been verified by a third-party service, please click on the "Verified" symbol in some Experts' profiles. JustAnswer is not intended or designed for EMERGENCY questions which should be directed immediately by telephone or in-person to qualified professionals.

JustAnswer in the News:

Ask-a-doc Web sites: If you've got a quick question, you can try to get an answer from sites that say they have various specialists on hand to give quick answers... Justanswer.com.
JustAnswer.com...has seen a spike since October in legal questions from readers about layoffs, unemployment and severance.
Web sites like justanswer.com/legal
...leave nothing to chance.
Traffic on JustAnswer rose 14 percent...and had nearly 400,000 page views in 30 days...inquiries related to stress, high blood pressure, drinking and heart pain jumped 33 percent.
Tory Johnson, GMA Workplace Contributor, discusses work-from-home jobs, such as JustAnswer in which verified Experts answer people’s questions.
I will tell you that...the things you have to go through to be an Expert are quite rigorous.

What Customers are Saying:

Wonderful service, prompt, efficient, and accurate. Couldn't have asked for more. I cannot thank you enough for your help.

Mary C.Freshfield, Liverpool, UK

This expert is wonderful. They truly know what they are talking about, and they actually care about you. They really helped put my nerves at ease. Thank you so much!!!!

AlexLos Angeles, CA

Thank you for all your help. It is nice to know that this service is here for people like myself, who need answers fast and are not sure who to consult.

GPHesperia, CA

I couldn't be more satisfied! This is the site I will always come to when I need a second opinion.

JustinKernersville, NC

Just let me say that this encounter has been entirely professional and most helpful. I liked that I could ask additional questions and get answered in a very short turn around.

EstherWoodstock, NY

Thank you so much for taking your time and knowledge to support my concerns. Not only did you answer my questions, you even took it a step further with replying with more pertinent information I needed to know.

RobinElkton, Maryland

He answered my question promptly and gave me accurate, detailed information. If all of your experts are half as good, you have a great thing going here.

DianeDallas, TX

< Previous | Next >

Meet the Experts:

Curtis B.

Curtis B.

Technician

1,921 satisfied customers

Technican turned service manager with multiple lines of equipment and rental units.

Wayne

Wayne

Journeyman

14,708 satisfied customers

worked on many road graders, Bull dozers , skid steers, Rollers

Cat Man

Cat Man

Cat Engine Expert

571 satisfied customers

I am ASE Master Certified.

dieseldan55

dieseldan55

Mechanic

294 satisfied customers

Road Mechanic for Volvo Construction Equipment.

Chris (aka- Moose)

Chris (aka- Moose)

Technician

44 satisfied customers

24 years of experience diagnosing & repairing

Steve

Steve

Mechanic

42 satisfied customers

Heavy Equipment Mechanic for 25 years

JBFixxer

JBFixxer

Mechanic

22 satisfied customers

16+ years experience, hydraulics,hydrostatics, engines, fuel injection systems. And everything in between.

< Previous | Next >

Disclaimer: Information in questions, answers, and other posts on this site ("Posts") comes from individual users, not JustAnswer; JustAnswer is not responsible for Posts. Posts are for general information, are not intended to substitute for informed professional advice (medical, legal, veterinary, financial, etc.), or to establish a professional-client relationship. The site and services are provided "as is" with no warranty or representations by JustAnswer regarding the qualifications of Experts. To see what credentials have been verified by a third-party service, please click on the "Verified" symbol in some Experts' profiles. JustAnswer is not intended or designed for EMERGENCY questions which should be directed immediately by telephone or in-person to qualified professionals.

Show MoreShow Less

Ask Your Question

x