Construction and Road Equipment

Construction and road equipment repair questions? Ask a mechanic ASAP

Connect one-on-one with {0} who will answer your question

Related Construction and Road Equipment Questions
I've got a Cat 416 (SN#05PC05983) transmission (GN#6y2598
I've got a Cat 416 (SN#05PC05983) transmission (GN#6y2598 SN#B80413). It won't go forward or reverse. I've cleaned the screen (which got me back up in going in the past, replaced the oil and filter. The linkage seems good. I pulled the neutral solenoid and made sure the pin is i retracted(I've left it disconnected). I removed the transmission control group, checked I'll springs and orifices, that all looked good. I did the pressure tap tests with these results (all are in PSI) Forward clutch 35, reverse clutch 55, pump @ idle 140 idle/[email protected], torque inlet 30 @ idle/[email protected] 1800, torque outlet 50, coolant 15. Can you tell me what these readings indicate? Much appreciated, AJ … read more
Curtis B.
Curtis B.
Technician
Associate Degree
2,195 satisfied customers
I have a 320 loader and it just stopped going forward and
I have a 320 loader and it just stopped going forward and back. I use it very little. I checked the tranny valves and there not getting grounded. I ram power and grd to the forward upper soliniod to g… read more
Dan
Dan
Technician
Auto Mechanics 1&2/diesel mech
13,374 satisfied customers
Deere 410 Backhoe weak on forward but can not stall engine
John Deere 410 Backhoe weak on forward but can not stall engine in forward motion. 165 # 0f oil pressure to clutch but acts like slipping in forward. All OK in reverse. Checked forward with air pressu… read more
Curtis B.
Curtis B.
Technician
Associate Degree
2,195 satisfied customers
I just rebuilt transmission of L150E Once I start the
Hi I just rebuilt transmission of L150E Once I start the machine I test the pressures of the tranny The confusing thing is I got only forward clutch at the right spec pressure which is 196psi The rest… read more
Curtis B.
Curtis B.
Technician
Associate Degree
2,195 satisfied customers
I have a Cat 163H that won't go in reverse in any gear. All
I have a Cat 163H that won't go in reverse in any gear. All gears going forward work fine. Tried swapping solenoids on the control valve still no reverse. All pressures check good on the test ports on… read more
catmastertech
catmastertech
Field service technician
Vocational, Technical or Trade Scho
1,317 satisfied customers
My Ford 555-D backhoe/loader engages well in forward and
My Ford 555-D backhoe/loader engages well in forward and reverse upon start-up with no slippage under power. As it warms up it seems to go in neutral when I let up on the power. Then as I apply power,… read more
Curtis B.
Curtis B.
Technician
Associate Degree
2,195 satisfied customers
Rebuilt transmission, Serial # 78G 2455 cat loader with
Serial # 78G 2455 cat loader with rebuilt transmission will only move 12 inches forward or backward.Changed seals on valve bank, transmission lever seems to be engaging. … read more
catmastertech
catmastertech
Field service technician
Vocational, Technical or Trade Scho
1,317 satisfied customers
I have a Cat 416 loader backhoe that won't take reverse.
I have a Cat 416 loader backhoe that won't take reverse. This started with hesitating when put in reverse, then pickup and go. The tractor will now pull forward fine but won't take reverse.… read more
Bradley Martin
Bradley Martin
77 satisfied customers
Transmissions ZF WG180 transmission: We have rebuilt a ZF WG180
We have rebuilt a ZF WG180 transmission in an 18 tonne loader, replacing the 1st and 2nd clutch packs and had an auto electrician check all of the electrical wiring and said everything was ok. But the… read more
Curtis B.
Curtis B.
Technician
Associate Degree
2,195 satisfied customers
International 125C track loader with a power shift
International 125C track loader with a power shift transmission. Very strange thing, the opposite of what is normally the issue. It only happens after the transmission gets good and warm. When I shift… read more
Dan
Dan
Technician
Auto Mechanics 1&2/diesel mech
13,374 satisfied customers
it28f cat wheel loader ran while the stop going forward
it28f cat wheel loader ran while the stop going forward but will go in reverse shut key off and on then works in forward again minutes or so… read more
catmastertech
catmastertech
Field service technician
Vocational, Technical or Trade Scho
1,317 satisfied customers
I have a Case 570 MXT loader landscaper I just purchased the
I have a Case 570 MXT loader landscaper I just purchased the tractor from a local dealer. When you first start up, the transmission slips. This lasts for about 2-5 minutes and then works fine for the … read more
Dan
Dan
Technician
Auto Mechanics 1&2/diesel mech
13,374 satisfied customers
I have a 300 d john deere backhoe . it will only moves in reverse
I have a 300 d john deere backhoe . it will only moves in reverse replaced clutches now moves forward only in low gear still slipping . wondering if revewrser solenoid bad… read more
Curtis B.
Curtis B.
Technician
Associate Degree
2,195 satisfied customers
cat 416 backhoe ser #5pc01396 trans #6t5584 I read the popup
cat 416 backhoe ser #5pc01396 trans #6t5584 I read the popup article but I think this machine is older It has reverse but no forward, filter was checked & appeared to have rubber in it.… read more
catmastertech
catmastertech
Field service technician
Vocational, Technical or Trade Scho
1,317 satisfied customers
Volvo L 50 B loader has very low torque to wheels. We think
Volvo L 50 B loader has very low torque to wheels. We think it is a control problem. It is a Model 11007612, Sert # XXXXX 94280, Seril # XXXXX How should we check hydrolic motor contols?… read more
dieseldan55
dieseldan55
Mechanic
Vocational, Technical or Trade Scho
298 satisfied customers
I have a Dresser 125G. Brakes have not functioned since I
I have a Dresser 125G. Brakes have not functioned since I bought it and it was very slow steering left. I have been using it for light work spreading crushed materials on forest roads. and recently it… read more
Dan
Dan
Technician
Auto Mechanics 1&2/diesel mech
13,374 satisfied customers
Hello, we have a Caterpillar 311b with some hydraulic issues,
Hello, we have a Caterpillar 311b with some hydraulic issues, here are the symptoms- with travel just slightly engaged(direction doesn't matter, same symptoms forwards or reverse), machine not moving,… read more
Dan
Dan
Technician
Auto Mechanics 1&2/diesel mech
13,374 satisfied customers
I have just purchased a very old Cat 955 track loader. We cannot
I have just purchased a very old Cat 955 track loader. We cannot find a serial number. It runs good and has good hydraulics. The machine simply will not move forward or reverse under even a slight loa… read more
Dan
Dan
Technician
Auto Mechanics 1&2/diesel mech
13,374 satisfied customers
Disclaimer: Information in questions, answers, and other posts on this site ("Posts") comes from individual users, not JustAnswer; JustAnswer is not responsible for Posts. Posts are for general information, are not intended to substitute for informed professional advice (medical, legal, veterinary, financial, etc.), or to establish a professional-client relationship. The site and services are provided "as is" with no warranty or representations by JustAnswer regarding the qualifications of Experts. To see what credentials have been verified by a third-party service, please click on the "Verified" symbol in some Experts' profiles. JustAnswer is not intended or designed for EMERGENCY questions which should be directed immediately by telephone or in-person to qualified professionals.

JustAnswer in the News:

Ask-a-doc Web sites: If you've got a quick question, you can try to get an answer from sites that say they have various specialists on hand to give quick answers... Justanswer.com.
JustAnswer.com...has seen a spike since October in legal questions from readers about layoffs, unemployment and severance.
Web sites like justanswer.com/legal
...leave nothing to chance.
Traffic on JustAnswer rose 14 percent...and had nearly 400,000 page views in 30 days...inquiries related to stress, high blood pressure, drinking and heart pain jumped 33 percent.
Tory Johnson, GMA Workplace Contributor, discusses work-from-home jobs, such as JustAnswer in which verified Experts answer people’s questions.
I will tell you that...the things you have to go through to be an Expert are quite rigorous.

What Customers are Saying:

Wonderful service, prompt, efficient, and accurate. Couldn't have asked for more. I cannot thank you enough for your help.

Mary C.Freshfield, Liverpool, UK

This expert is wonderful. They truly know what they are talking about, and they actually care about you. They really helped put my nerves at ease. Thank you so much!!!!

AlexLos Angeles, CA

Thank you for all your help. It is nice to know that this service is here for people like myself, who need answers fast and are not sure who to consult.

GPHesperia, CA

I couldn't be more satisfied! This is the site I will always come to when I need a second opinion.

JustinKernersville, NC

Just let me say that this encounter has been entirely professional and most helpful. I liked that I could ask additional questions and get answered in a very short turn around.

EstherWoodstock, NY

Thank you so much for taking your time and knowledge to support my concerns. Not only did you answer my questions, you even took it a step further with replying with more pertinent information I needed to know.

RobinElkton, Maryland

He answered my question promptly and gave me accurate, detailed information. If all of your experts are half as good, you have a great thing going here.

DianeDallas, TX

< Previous | Next >

Meet the Experts:

Curtis B.

Curtis B.

Technician

2,195 satisfied customers

Technican turned service manager with multiple lines of equipment and rental units.

Wayne

Wayne

Journeyman

1,172 satisfied customers

worked on many road graders, Bull dozers , skid steers, Rollers

Cat Man

Cat Man

Cat Engine Expert

575 satisfied customers

I am ASE Master Certified.

dieseldan55

dieseldan55

Mechanic

298 satisfied customers

Road Mechanic for Volvo Construction Equipment.

Chris (aka- Moose)

Chris (aka- Moose)

Technician

52 satisfied customers

24 years of experience diagnosing & repairing

Steve

Steve

Mechanic

42 satisfied customers

Heavy Equipment Mechanic for 25 years

JBFixxer

JBFixxer

Mechanic

22 satisfied customers

16+ years experience, hydraulics,hydrostatics, engines, fuel injection systems. And everything in between.

< Previous | Next >

Disclaimer: Information in questions, answers, and other posts on this site ("Posts") comes from individual users, not JustAnswer; JustAnswer is not responsible for Posts. Posts are for general information, are not intended to substitute for informed professional advice (medical, legal, veterinary, financial, etc.), or to establish a professional-client relationship. The site and services are provided "as is" with no warranty or representations by JustAnswer regarding the qualifications of Experts. To see what credentials have been verified by a third-party service, please click on the "Verified" symbol in some Experts' profiles. JustAnswer is not intended or designed for EMERGENCY questions which should be directed immediately by telephone or in-person to qualified professionals.

Show MoreShow Less

Ask Your Question

x